Engine warning light on then off

This section is for technical Q & A
Please try the search function before starting a new thread.
Forum rules
Many subjects will have been discussed before. Please try the search function before starting a new thread.
Check in the Know Your 2 as the information you need may already be there.
Important ! - Please make your topic title as descriptive as possible . titles with just "help" generally dont get as many answers as a title that points to the problem
The forum Administrator has chosen to advise you that this topic is 5 years and 2 months old and that you may wish to begin a new topic or use the search feature to find a similar but newer topic.

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Engine warning light on then off

Post by SteveandDebra1 »

Hi all. I have owned a 1990 mk2 N/A for the past ten years and a couple of months ago decided to buy a 1992 Turbo. All has been fine until today when I started the engine. The amber engine warning light came on after about ten seconds running. I stopped and checked for obvious faults (broken sensor wires etc) but could not find anything obvious so carried on and got home.
I noticed whils't travelling home every time my after market turbo boost pressure went positive the amber light went out, but as soon as I lifted off the throttle it came back on again. Once home I done a diagnostic checkto see what fault codes were stored but there weren't any.
The car runs and performs perfectly but still the fault light comes on when Iam not in positive turbo pressure.
Anyone got any ideas were to start. :sad:
Regards Steve.



notroubleclubber
Posts: 1029
Joined: 31/07/09 7:36
Years of MR2 Ownership: 8
MR2's Owned: 3
Real Name: Mark
Gender: Male

Re: Engine warning light on then off

Post by notroubleclubber »

1992, bring a rev 2 turbo?
In which case check the ecu for blown capacitors as VERY common problem.

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Re: Engine warning light on then off

Post by SteveandDebra1 »

Many thanks for your reply. As an electrinic engineer could you point me in the right direction as to what cap to replace. I am confident that I could replace a capacitor, if I knew it's location and value.
Again Many Thanks. Regards Steve.
User avatar

jimi
Administrator
Administrator
Posts: 5167
Joined: 17/05/04 1:00
Years of MR2 Ownership: 18
MR2's Owned: 1
Gender: Male
Location: Glenrothes: The Kingdom of Fife
Has thanked: 45 times
Been thanked: 116 times
Contact:

Re: Engine warning light on then off

Post by jimi »

I wouldn't agree it's a "Very" common problem, I'd say becoming common. Anyway there's no (to my knowledge) particular cap that fails, the problem seems to be down to a few electrolytics that fail. Basically you need to open the Ecu and check the larger electrolytics for leakage or bulging sides/domed tops and if found replace them, values are usually legible on the caps. If you do find a problem with the ECU caps, please post pics, values etc, more documented info is really needed on this type of problem.
There's some more info on these threads
https://www.mr2oc.co.uk/forums/41/16665 ... r#p1765959

https://www.mr2oc.co.uk/forums/41/16259 ... r#p1717776
This thread may also help http://www.gt4dc.co.uk/forum/viewtopic.php?f=2&t=5617
Black is not a colour ! .... Its the absence of colour
Image

notroubleclubber
Posts: 1029
Joined: 31/07/09 7:36
Years of MR2 Ownership: 8
MR2's Owned: 3
Real Name: Mark
Gender: Male

Re: Engine warning light on then off

Post by notroubleclubber »

Disagree,,, VERY common problem.

In fact its been a problem on many a fb group especially the rev 2 within the last year though it seems to be affecting other revs now too. Try getting hold of a rev 2 turbo ecu these days.

Also loads of posts on many of the forums though they seem to be dying out these days so not posted on as much which is a shame.

S81933
Posts: 127
Joined: 18/09/15 9:42
Years of MR2 Ownership: 4
MR2's Owned: 1
Real Name: Don
Gender: Male
Location: Chelmsford, Essex
Has thanked: 1 time
Been thanked: 3 times

Re: Engine warning light on then off

Post by S81933 »

Please save my nerves - is this just a turbo problem, or could n/a suffer this same issue. :confused1:

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Re: Engine warning light on then off

Post by SteveandDebra1 »

Would a ECU marked 3S-GT 89661-17321 Replace a ECU marked 3S-GT 89661-380
Regards Steve

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Re: Engine warning light on then off

Post by SteveandDebra1 »

Hi all. Opened the ECU and found 3 leaking electrolitic caps. 2 on the small board and 1 on the larger. Cleaned around the caps with a fibreglass commutator stick and on replacement everything is fine, no warning light.
But tracks on the board are well eaten away, so a replacement will soon be required.
Would a ECU marked 3S-GT 89661-17321 replace mine marked 3S-GT 89661-380.
Does anyone know what the differences are.
Regards Steve.
User avatar

jimi
Administrator
Administrator
Posts: 5167
Joined: 17/05/04 1:00
Years of MR2 Ownership: 18
MR2's Owned: 1
Gender: Male
Location: Glenrothes: The Kingdom of Fife
Has thanked: 45 times
Been thanked: 116 times
Contact:

Re: Engine warning light on then off

Post by jimi »

If it's just the caps and a bit of track damage then your ECU should be repairable by anyone competent in electronics. These threads may help
https://www.imoc.co.uk/forums/viewtopic.php?t=193914&
https://www.imoc.co.uk/forums/viewtopic.php?t=186927

Without knowing your VIN number I can't cross check properly in the Toyota EPC (Electronic Parts Catalogue) which is the correct ECU for your car, however I can say this 89661-17321 is a JDM turbo ECU for 1990-1991 3S-GTE

Image

on the other hand the number you quoted 89661-380 isn't correct, not enough numbers in the second part, when I try it in the EPC I get
"Invalid part number; a part number must contain 10 or 12 digits or letters."

Taking an educated guess it should be 89661-17380 which is a JDM turbo ECU for 1991-1993 3S-GTE

Image

I don't know if the earlier ECU will work in your car, if you PM me your VIN number I'll check which number ECU your car should have.
Black is not a colour ! .... Its the absence of colour
Image

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Re: Engine warning light on then off

Post by SteveandDebra1 »

Hi . Many thanks for your replies and useful links.
Last edited by SteveandDebra1 on 21/01/19 20:17, edited 1 time in total.

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Re: Engine warning light on then off

Post by SteveandDebra1 »

Ps How do I attach a picture to my posts. Cheers
User avatar

abovetherim
Posts: 848
Joined: 29/01/11 18:53
Years of MR2 Ownership: 9
MR2's Owned: 1
Real Name: Jan Olsson
Gender: Male
Location: Leicester
Been thanked: 1 time

Re: Engine warning light on then off

Post by abovetherim »

Find a photo hosting site that allow embedding. Not photobucket.
Then paste the IMG link into the post.
1991 rev 1 T Bar n/a 3sge import. A work in progress!!!

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Re: Engine warning light on then off

Post by SteveandDebra1 »

Hi. I have managed to get a Ecu part number 89661-17280. Mine is a part number 89661-17380. Does anyone know if this will replace mine. I am told it’s from jdm 1992 turbo mk2 Rev 2 import which is what mine is, but don’t want to fit it without some info.
Regards Steve

Topic author
SteveandDebra1
Full Member
Full Member
Posts: 57
Joined: 04/12/18 16:23
Years of MR2 Ownership: 11
MR2's Owned: 2
Real Name: Steve
Gender: Male
Location: Ashford Kent
Has thanked: 2 times

Re: Engine warning light on then off

Post by SteveandDebra1 »

Any info please.
Regards Steve

Quick Reply

   
The forum Administrator has chosen to advise you that this topic is 5 years and 2 months old and that you may wish to begin a new topic or use the search feature to find a similar but newer topic.

Return to “MK2”